検索対象:     
報告書番号:
※ 半角英数字
 年 ~ 
 年

固体廃棄物処理技術開発施設(LEDF)の合理化設計: セル消火実証試験

The rationalization design of large equipment dismantling facility (LEDF); Demonstration test on extinguishing of the cell (II)

瀧田 孝治; 堂野前 寧 ; 松本 誠弘; 菊地 豊 ; 加藤 徳義; 宮崎 仁; 谷本 健一

not registered; not registered; Matsumoto, Yoshihiro; not registered; Kato, Noriyoshi; Miyazaki, Hitoshi; Tanimoto, Kenichi

固体廃棄物処理技術開発施設(LEDF)のセル消化設備の気化器は、コストが高く施設の合理化設計の一環として削減する計画としている。気化器を削減した場合、液化炭酸ガスをセル内に直接放出することとなり、放出した液化炭酸ガスの急激な気化膨張によるセル内の圧力挙動及び消化性能を把握する必要がある。そこで、火災実験室を用いて平成11年度にセル消化実証試験(I)として、液化炭酸ガス放出時の火災実験室内の圧力挙動と可燃物燃焼時の消化性能を確認した。しかし、この試験は機密性のない火災実験室で実施したため、さらに実際のセルを想定した機密性の高い条件下での液化炭酸ガス放出時の圧力挙動を把握する必要がある。このため、大洗工学センター内の大型密封装置(SOLFA-2)を用いてセル消化実証試験(II)を実施した。 得られた成果は、以下の通りである。1)槽内の圧力挙動を把握するため、SOLFA-2の内部圧力は-50mmH2Oに設定し液化炭酸ガスを放出した。その結果、槽内圧力は液化炭酸ガス放出直後に急激に下降し、その後徐々に上昇して短時間で急上昇過程を経てなだらかに下降するという傾向が見られた。2)上記の短時間で急上昇する過程は、槽内に放出した液化炭酸ガスの一部がドライアイスに変化して堆積したものが周囲の熱を奪い昇華して、再び気化することが主な要因と考えられる。3)槽内最低平均温度は全域放出方式において約-48$$^{circ}C$$となり、局所放出方式では約-60$$^{circ}C$$となった。4)セル内圧力を負圧保持する条件として、液化炭酸ガス放出量を槽内空気の排気流量に対し、約85%に設定することで、負圧を維持できることを見出した。5)槽内圧力の急激な上昇を抑制するには、液化炭酸ガスをゆっくり放出することが効果的であることがわかった。

The vaporizer in extinguishing of Large Equipment Dismantling Facility (LEDF)that cost is considering as a plan to cut down as part of a rationalization design highly. When the vaporizer is deleted, it becomes here where liquefied carbon dioxide is emitted in the direct cell, it is necessary to grasp the action and extinguishing performance of the pressure change in the cell by rapid evaporation test of the emitted liquefied carbon dioxide. So pressure action inside the fire laboratory in liquefied carbon dioxide release and a putting out the fire tests due to the combustion time of the combustible were enforced by using the general fire laboratory with Demonstration Test on Extinguishing of the cell (I) in the llth year of Heisei. However, since these tests are after laboratory without airtightness, it needs to grasp the pressure action at the time of liquefied carbon dioxide discharge under the airtight high conditions of having assumed the still more nearly actual cell. The cell (II) Demonstration Test on Extinguishing using the vessel of Sodium Leak Fire and Aerosol test rig (SOLFA-2) container inside of OEC was carried out. The results were as follows. (1)In order to grasp the pressure action of the vessel, the internal pressure of SOLFA-2 was set as -50mmH$$_{2}$$O, and emitted liquefied carbon dioxide. Consequently, the tendency for the pressure in the vessel to descend rapidly immediately after liquefied carbon dioxide discharge, and to descend gently-sloping through the process which goes up gradually after that and goes abruptly up for a short time was seen. (2)The process which goes abruptly up in an above-mentioned short time is considered to be the factors with main what some liquefied carbon dioxide emitted in the vessel changed to dry ice, and was deposited taken and sublimating surrounding heat, and evaporating again. (3)It sets to total flooding system and the average minimum temperature in the vessel becomes about -48$$^{circ}$$C, and at ...

Access

:

- Accesses

InCites™

:

Altmetrics

:

[CLARIVATE ANALYTICS], [WEB OF SCIENCE], [HIGHLY CITED PAPER & CUP LOGO] and [HOT PAPER & FIRE LOGO] are trademarks of Clarivate Analytics, and/or its affiliated company or companies, and used herein by permission and/or license.