Initialising ...
Initialising ...
Initialising ...
Initialising ...
Initialising ...
Initialising ...
Initialising ...
Nemoto, Takahiro; Fujiwara, Yusuke; Arakawa, Ryoki; Choyama, Yuya; Nagasumi, Satoru; Hasegawa, Toshinari; Yokoyama, Keisuke; Watanabe, Masashi; Onishi, Takashi; Kawamoto, Taiki; et al.
JAEA-Technology 2024-003, 17 Pages, 2024/06
JAEA-Technology-2024-003.pdf:1.91MB
In order to investigate the cause of the increase in differential pressure in the primary helium circulator filter that occurred during the RS-14 cycle, a clogged filter was investigated. As a result of the investigation, deposits caused by silicone oil were confirmed on the surface of the filter element. These results revealed that the cause of filter clogging was silicone oil mixed into the primary system due to performance deterioration of the charcoal filter in the gas circulator of primary helium purification system. As a measure to prevent the recurrence of this event, in addition to the conventional management based on operating hours for replacing of charcoal filter in the gas circulator of primary helium purification system, we have established a new replacement plan for every three years.
Nemoto, Takahiro; Arakawa, Ryoki; Kawakami, Satoru; Nagasumi, Satoru; Yokoyama, Keisuke; Watanabe, Masashi; Onishi, Takashi; Kawamoto, Taiki; Furusawa, Takayuki; Inoi, Hiroyuki; et al.
JAEA-Technology 2023-005, 33 Pages, 2023/05
JAEA-Technology-2023-005.pdf:5.25MB
During shut down of the HTTR (High Temperature engineering Test Reactor) RS-14 cycle, an increasing trend of filter differential pressure for the helium gas circulator was observed. In order to investigate this phenomenon, the blower of the primary helium purification system was disassembled and inspected. As a result, it is clear that the silicon oil mist entered into the primary coolant due to the deterioration of the charcoal filter performance. The replacement and further investigation of the filter are planning to prevent the reoccurrence of the same phenomenon in the future.
Furusawa, Takayuki; Sumita, Junya; Ueta, Shohei; Nemoto, Takahiro; Oyama, Sunao*; Kamata, Takashi
JAERI-Tech 2004-024, 46 Pages, 2004/03
JAERI-Tech-2004-024.pdf:6.75MB
Primary helium circulators of the HTTR are the important component as the helium gas which is reactor coolant, and three circulators for the primary pressurized water cooler and one for the intermediate heat exchanger are installed in primary cooling system. In the upstream of these circulators, the filter has been installed in order to suppress that it is entrapped in the bearing in which fine particles in helium gas, support main shaft of the helium circulator. The differential pressure of this filter rose gradually during rise-to-power test. The rise of the filter differential pressure of the helium circulator may cause the problem for reactor operation. Therefore, the filters were newly manufactured, and replacement of the filter was carried out. In replacement of the filter, appearance confirmation was carried out and deposit of the filter was analyzed. This paper described replacement of the filter and filter differential pressure rise investigation of the causes.